Water Heat Recovery System

Water heat recycling also known as drain water heat recovery waste water heat recovery greywater heat recovery citation needed or sometimes shower water heat recovery citation needed is the use of a heat exchanger to recover energy and reuse heat from drain water from various activities such as dish washing clothes washing and especially showers.

Water heat recovery system.

Water heating accounts for approximately 20 to 30 percent of household energy demand. This is a simple diagram of how a drain water heat recovery system works diagram courtesy of ecodrain. Heat recovery ventilation hrv also known as mechanical ventilation heat recovery mvhr is an energy recovery ventilation system which works between two sources at different temperatures. A system normally takes the form of a long vertical copper pipe.

The energy department estimates that energy losses in hot water amount to 80 to 90 a good argument for installing a drain water heat recovery dhr system. This heat is used to warm the incoming mains water reducing the strain on your boiler and the energy required to heat your water up to temperature. At 20 30 of home energy consumption water heating is typically the 2nd highest energy demand. Made in the usa.

Drain water heat recovery technology works well with all types of water heaters especially with demand and solar water heaters. Maximizer systems specializes in the design manufacture and installation of waste water heat recovery systems. Waste water heat recovery allows you to capture waste energy from waste hot water normally lost to the drain or sewer system. Typically a waste water heat recovery system works by extracting the heat from the water your shower or bath sends down the drain.

The power pipe can dramatically cut water heating costs and reduce total home energy consumption by 5 10. They had previously installed a heat recovery system but this had failed due to fouling and ultimate blocking of the heat exchanger airways with fibres and condensed oils. Makes the most hot water available. Operational s waste heat recovery solution was to install a fully integrated heat recovery ventilation system using a low pressure hot water run around system to transfer.

In a gravity film heat exchanger gfx drain water flows through a copper pipe that is wrapped in smaller diameter copper tubing. Stratified tank water near the top is the hottest makes for quick recovery and efficient heat transfer. It works by using outgoing warm drain water to pre heat incoming cold fresh water so your water heater doesn t have to work as hard. Drain water heat exchangers can recover heat from the hot water used in showers bathtubs sinks dishwashers and clothes washers.

Heat recovery is a method which is increasingly used to reduce the heating and cooling demands and thus energy costs of buildings. Heat from the drain water is transferred to incoming water.